Recalls For 2005 TOYOTA SIENNA
Here are the vehicle recalls we have for the 2005 TOYOTA SIENNA. If you have any questions, do not hesitate to Contact Us:
Recall #1 Issued: 2005 07 20
Description Of Defect
ON CERTAIN MINI VANS, IN THE MIDDLE ROW SEATING POSITION, THE SHOULDER PORTION OF THE SEAT BELT MAY BIND IN THE BEZEL TRIM PIECE. THE AFFECTED SEAT BELT BEZEL IS LOCATED ON THE SHOULDER PORTION OF THE SEAT IN THE RIGHT SIDE SEAT OF THE SEVEN PASSENGER MODELS AND THE CENTER SEATING POSITION IN THE EIGHT PASSENGER MODELS.
Conseqence Of Defect
IF THE SEAT BELT BINDS IN THE BEZEL, THAT EXTRA WEBBING MAY EXIST IN THE SEAT BELT WHICH COULD RESULT IN AN IMPROPERLY FITTED SEAT BELT ON A PASSENGER. IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Action
DEALERS WILL REPLACE THE SEAT BELT BEZEL AND CLIP. THE RECALL BEGAN AUGUST 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Additional Notes
TOYOTA RECALL NO. 50L.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Recall #2 Issued: 2008 06 03
Description Of Defect
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Conseqence Of Defect
IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Corrective Action
DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Additional Notes
TOYOTA NO. 80C.THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. HOWEVER, TOYOTA HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE FREE OF CHARGE.
Recall #3 Issued: 2009 06 25
Description Of Defect
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Conseqence Of Defect
THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Corrective Action
TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Additional Notes
RECALL NUMBER SSC 9LF.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Recall #4 Issued: 2010 02 03
Description Of Defect
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Conseqence Of Defect
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Corrective Action
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Additional Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Recall #5 Issued: 2010 02 03
Description Of Defect
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Conseqence Of Defect
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Corrective Action
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Additional Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Recall #6 Issued: 2010 04 20
Description Of Defect
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Conseqence Of Defect
THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Action
TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Additional Notes
TOYOTA RECALL NO. AOE.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Recall #7 Issued: 2011 11 09
Description Of Defect
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Conseqence Of Defect
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Corrective Action
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Additional Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Tweet